Conquering the ‘Killer Corsair’: A Naval Victory
Amidst the chaos of World War II’s skies, a mere speck of aluminum solved the Wright brothers’ ambitious problem.
The initial carrier-landing trials for the Chance Vought F4U Corsair proved disastrous. In the fall of 1942, Lieutenant Commander Sam Porter evaluated the feasibility of operating the Navy’s bent-wing fighter from the deck of the escort carrier USS Sangamon in the Chesapeake Bay. After four terrifying landings, he decided to stop, convinced the airplane was about to kill him.
The Corsair’s cockpit was so far back in its fuselage that Porter found it difficult to see the Sangamon’s landing signal officer on the port side of its deck. The fighter’s ultra-long “hose nose” made it nearly impossible for the pilot to get timely feedback to make corrections to his approach.
When the Corsair thumped down on the deck, the landing gear’s oleos—shock-absorbing struts—bottomed out, then bounced back like giant pogo sticks, causing the airplane to bound over the arresting wires. If other aircraft had been parked on the forward part of the Sangamon’s flight deck, there would have been a pile-up.
But the compromised visibility and wild bounce didn’t frighten Porter as much as the airplane’s behavior during the moments in between. Seconds from touchdown, flying slow and low, with flaps, gear, and arresting hook buzzing in the slipstream, the Corsair suddenly stalled. And the way it stalled would have terrified any pilot.
As the airspeed bleeds off, the left wing—with almost no advance warning—lost lift, rolling the airplane abruptly toward port.
Porter rightly feared that when a less experienced aviator was faced with the Corsair’s nasty behavior, he would instinctively jam the throttle forward in a desperate attempt to grab raw horsepower to claw his way out of trouble. The sudden torque unleashed from the fighter’s powerful R-2800 engine and its 13-foot, 4-inch propeller would exacerbate the aircraft’s uncontrollable tendency to yaw just feet above the waves. That would have been a deadly predicament that not even the most skillful flyer could escape from.
As current surged, the Corsair was a deathtrap, living up to its nickname: “Ensign Eliminator.” At the 2011 Planes of Fame Airshow in California, Corsairs flew a formation pass. The burly Corsair entered Navy service as a murderously hard-hitting hellion; once tamed, it became a legend. Today, it’s an airshow favorite.
The vicious asymmetric stall was quickly mitigated once the forces acting on the aircraft were fully understood. The fighter’s most precarious blade, digging into the air, shoved a twisting spiral of prop wash aft that resulted in dissimilar airflow over the wings. The left wing lost lift first, and it happened fast. But countering that stall was tricky. The Corsair descended to the deck at a dramatic nose-up angle of attack (up to 17 degrees). At the slow speed required for landing and in that unusual attitude, the airplane’s control surfaces were all but useless in these crucial moments before touchdown.
Vought engineers and the Navy analysts participating in the carrier trials realized that they would have to determine the airflow over the “good,” or starboard, wing—causing the Corsair’s wings to ɩіѕһ simultaneously. In order to do it, a spoiler, or “stall strip,” was affixed to the leading edge of the starboard wing, just outboard of the gun ports. Only about six inches long and about three inches wide, the simple triangular strip degraded the aerodynamic performance of the right wing and made its lift match that of the left. Thereafter, the Corsair behaved predictably; that is to say, it ѕtаɩɩɘɖ symmetrically. Even with a stall strip, the Corsair was cantankerous. On the USS Sicily in October 1949, the landing signal officer and assistant fleet as a Marine pilot watches a landing and crashes. Miraculously, the pilot survived.
In late 1942 and early 1943, sailors fashioned the first versions of the stall strip from simple blocks of wood for Corsairs already in service, while assembly lines at Vought, Goodyear, and Brewster soon added factory-built metal stall strips to each new airframe.
Despite more hair-raising attempts to make the Corsair carrier-ready, conducted by Navy squadrons VF-12 and VF-17, most of the original airframe found a home in Marine Corps combat squadrons flying from—and more importantly, landing on—island bases.
Over time, Vought engineers and men in the field implemented upgrades to the promising but troubled fighter. Greater air pressure in the airplane’s landing gear oleo eliminated much of the pronounced bounce. For a better view from the cockpit, decisions replaced the “birdcage” canopy with a frameless clear bubble. The additional headspace allowed the pilot’s seat to be raised by eight inches. An improved F4U-1A was in the Pacific with the Marines in the summer of 1943.
The turning point arrived with the emergence of the British Royal Navy’s Fleet Air Arm, armed with the concept to bring Corsairs to see duty for good. The pilots developed a long, cunning landing approach to keep the carrier’s deck in sight until the last moments before touchdown.
Corsairs did not operate from U.S. Navy carriers until 1944. Despite improvements, the fighter was never a pushover during landing. Skilled pilots found ways to slice, bounce, or flip their Corsairs in these nerve-wracking seconds of final approach. Flight deck crews sacrificed sleep, courage, and range.
When the bugs were ironed out, the F4U hit its stride. Flight’s venerable “U-Bird” went on to become one of the best naval fighters of World War II, racking up 2,140 victories in aerial combat. Only 189 Corsairs were lost to enemy aircraft. Aces like Gregory “Pappy” Boyington, Robert Hanson, and Kenneth Walsh each claimed more than 20 victories, making the Corsair nearly as fearsome as the much-revered P-51 Mustang and flashy P-38 Lightning.
Outboard of the gun ports on the Corsair’s flight wing, a little scrap of metal, carefully shaped and faired, spoiled lift just enough to make the wings stall simultaneously and make the Corsair less unpredictable. In 1951, Navy Carrier Air Group 2 embarked with a deckload of Corsairs on the USS Philippine Sea. Like some of its pilots, the Corsair earned fame in World War II and, season after season, fought again in Korea.
As the war progressed, the range of duties for the Corsair broadened. Like today’s multi-role aircraft, the Corsair could protect the fleet from enemy assaults and assume the attack role, lugging bombs to targets like Iwo Jima, Okinawa, and the Japanese home islands.
On December 15,621 tons of bombs fell on the enemy, which made up 70 percent of the total bombs delivered by all U.S. fighters in any theater. This versatility, combined with stellar performance and the potential for future upgrades, was one of the main factors that helped keep the Corsair flying in Navy and Marine Corps squadrons long after its stablemate, the Grumman F6F Hellcat, disappeared from fleet service.
When fighting broke out in Korea in 1950, the Corsair was still on the front lines, often supporting troops on the ground with napalm, bombs, rockets, and gunfire. Though primarily operating in the role of close air support, Corsair pilots tangled with Russian-made fighters over Korea and were even dispatched in darkness to track down enemy harassment flights using radar. In 1952, Lieutenant Guy Bordelon Jr. became the U.S. Navy’s only Korean War ace when he shot down his fifth enemy in his Corsair night fighter nicknamed “Annie-Mo.”
In September of that year, Captain Jesse Folmar plunged his aging F4U-4B Corsair fighter into a turning dogfight with a MiG-15 jet. He came out on top, downing the speedier and more advanced aircraft with a burst of 20mm fire. His celebration was short-lived, as more MiGs swarmed in, blasting his Corsair. Folmar parachuted into the ocean, where he was almost immediately rescued.
Despite its age and laborious development process, the Corsair’s exceptional endurance at the dawn of the jet age was unparalleled. The last of 12,571 Corsairs rolled off the assembly line on January 31, 1953, earning the distinction of the longest production run of any piston-engine fighter in American history.
Hits: 15
